[1]咸利国,姚廷强,龚岸琦.螺旋锥齿轮减速箱系统振动分析[J].机械与电子,2017,(10):3-6.[doi:1001-2257(2017)10-0003-04]
　XIAN Liguo,YAO Tingqiang,GONG Anqi.Vibration Analysis of Spiral Bevel Gearbox System[J].Machinery & Electronics,2017,(10):3-6.[doi:1001-2257(2017)10-0003-04]
点击复制

螺旋锥齿轮减速箱系统振动分析
分享到：

《机械与电子》[ISSN:1001-2257/CN:52-1052/TH]

卷:
期数:
2017年10期
页码:
3-6
栏目:
设计与研究
出版日期:
2017-10-24

文章信息/Info

Title:
Vibration Analysis of Spiral Bevel Gearbox System
作者:
咸利国; 姚廷强; 龚岸琦
(昆明理工大学机电工程学院,云南 昆明 650093)
Author(s):
XIAN Liguo; YAO Tingqiang; GONG Anqi
(School of Mechanical and Electric Engineering, Kunming University of Science and Technology, Kunming 650093,China)
关键词:
减速箱系统;  润滑;  频谱;  振动
Keywords:
gearbox;  lubrication;  frequency;  vibration
分类号:
TG457.23
DOI:
1001-2257(2017)10-0003-04
文献标志码:
A
摘要:
以格里森制弧齿下的减速箱系统为对象,综合考虑圆锥滚子轴承在系统中的振动,运用设计的试验方法和试验设备,分析了润滑对整个减速箱系统输入端的振动幅值和频率特性影响,对后续减速箱系统振动的研究提供实验依据,从而进一步揭示减速箱系统振动的特性。试验表明,不同润滑状态对于振动频谱峰值影响很大,在低速无润滑状态下高频段频率为主振频率,低速油润滑状态下正好相反; 无润滑和油润滑状态在高速情况下总体变化趋势一致,但无润滑状态下的频率谱幅度比油润滑下的要高。
Abstract:
Taking the gearbox system of Gleason as the object, the study analyzed, by considering the vibration of taper roller bearing in the gearbox, and using the designed test method and equipment, the influence of lubrication in the whole gearbox on the vibration amplitude and frequency characteristics of the input end. It provided the experimental basis for the subsequent research and further revealed the vibration characteristics of the gearbox system. The test shows that different lubrication conditions influence greatly the peak vibration frequency. Under the circumstances of low speed and no lubrication, the high frequency is the master frequency, while under the condition of low speed and oil lubrication, the situation is the other way around; the overall change tendency in high speed is of consistency under the conditions of none lubrication and oil lubrication, whereas the frequency of non-lubricating condition is higher than that of oil lubrication.

参考文献/References:

[1]严珩志,王红志,钟掘.谐波振动下线接触弹流润滑的仿真及分析[J]. 摩擦学学报,2002,22(1): 62-65.
[2]张金梅,刘更.考虑啮入冲击作用下减速器的振动噪声分析[J].振动与冲击.2013,32(13):118- 122.
[3]周建星,孙文磊.单级人字齿轮加速器振动噪声影响因素研究[J].振动与冲击.2015,34(5):213- 219.
[4]赵联春,马家驹.润滑对球轴承振动特性的影响[J]. 摩擦学学报,2003,23(5):421-425.
[5]张万厚,李秀香.润滑油脂对轴承振动和噪声影响的初步探讨[J].洛阳轴承研究所.1983(1):36-39.

相似文献/References:

[1]周 雷.空管雷达高速天线座关键技术研究[J].机械与电子,2018,(02):34.
　ZHOU Lei.Research on Key Technology of High Speed Antenna Pedestal for Air Traffic Control Radar[J].Machinery & Electronics,2018,(10):34.

备注/Memo

备注/Memo:
收稿日期：2017-07-06
基金项目： 国家自然科学研究基金项目(11002062、11462008）
作者简介：咸利国（1991-），男，河北张家口人，硕士研究生，研究方向为机械系统动力学；姚廷强（1979-），男，四川资阳人，博士，副教授，研究方向为轴承动力学及其系统动力学。
更新日期/Last Update: 2017-10-25